CFC Chiller Phaseout Slows

April 24, 2002
/ Print / Reprints /
ShareMore
/ Text Size+
ARLINGTON, VA — The national economic downturn has slowed replacements of comfort cooling chillers that use CFCs. Manufacturers predict that by year’s end, 48% of the original 80,000 CFC chillers will still rely on these refrigerants, according to the Air-Conditioning and Refrigeration Institute (ARI).

ARI’s survey of large-tonnage liquid chiller manufacturers revealed that 2,931 CFC chillers were converted to non-CFC refrigerants or replaced by new non-CFC equipment during 2001, with 3,124 more expected in 2002. That leaves an estimated 38,281 CFC units still in use.

Release of the survey results followed recent publication of “Building Owners Save Money, Save the Earth,” a brochure by the U.S. Environmental Protection Agency (EPA). The brochure states, “A new energy-efficient chiller can easily pay for itself in electricity savings, improved reliability, and lower maintenance costs. Building owners can typically pay back the investment cost of replacing an old CFC chiller in five years or less in virtually all locations that cool for more than three months a year. In fact, replacement chillers can pay for themselves in as little as two or three years, with a typical return on investment of 20% to 35%.”

Chillers provide cooling in offices, malls, hospitals, airports, factories, sports complexes, government buildings, and institutions such as colleges. The EPA noted that “Building owners around the world have saved millions of dollars in electricity bills through careful choice of upgraded air conditioning chiller installations and through complementary investments to reduce building cooling load. Today’s chillers use about one-third or less electricity compared to those produced just two decades ago.”

Despite the cost savings, the pace of replacements and retrofits has been slower than expected. At the current rate, it will likely take manufacturers until the end of this decade to phase out the remainder. Manufacturers said that in 2002 they expect 360 conversions and 2,764 replacements, bringing the total to 41,719 units, or 52% of the original 80,000 CFC chillers in place in the early 1990s. (See Table 1.)

The 2001 global economic slowdown was reflected in the shipment of 7,171 non-CFC chillers for new buildings and CFC replacements here and abroad, a 7% decline compared to the 7,731 units shipped in 2000. However, factory shipments are at least double the pace of 15 years ago (in 1987 they totaled 3,744 units).

Before the introduction of non-CFC chillers more than 10 years ago, building owners typically chose units using CFC-11 or -12. EPA rules require recovery of those refrigerants, which can be used to service CFC units still in operation when the refrigerant is reclaimed to purity levels set in ARI Standard 700.

Use of alternative refrigerant, higher-efficiency chillers has saved billions of kWh of electricity annually in the United States, says the ARI. According to the EPA, “Building owners with obsolete CFC equipment compete for dwindling supplies of reclaimed refrigerants and parts — paying higher prices and risking refrigerant shortages. Savings from electricity costs alone pay back the investment at high rates of return — even at low energy prices.”

Publication date: 04/29/2002

Did you enjoy this article? Click here to subscribe to The NEWS Magazine

Recent Articles by Greg Mazurkiewicz

You must login or register in order to post a comment.

Multimedia

Videos

Image Galleries

2014 MCAA Annual Convention

Scenes from the 2014 MCAA Annual Convention in Scottsdale, Ariz.

Podcasts

NEWSmakers: Julian Scadden

Training is an ongoing process. Julian will discuss how you can generate maximum return on time and energy invested training by following a three part process. Listen to this podcast to get expert tips on training, tracking and follow up. 

More Podcasts

THE MAGAZINE

ACHRNEWS

NEWS 04-14-14 cover

2014 April 14

Check out the weekly edition of The NEWS today!

Table Of Contents Subscribe

SERVICE CALLS POLL

Which statement on service calls best applies to your business?
View Results Poll Archive

HVACR INDUSTRY STORE

plumbing-hvac.gif
2014 National Plumbing & HVAC Estimator

Every plumbing and HVAC estimator can use the cost estimates in this practical manual!

More Products

Clear Seas Research

 

Clear Seas ResearchWith access to over one million professionals and more than 60 industry-specific publications, Clear Seas Research offers relevant insights from those who know your industry best. Let us customize a market research solution that exceeds your marketing goals.

DON'T MISS A THING

Magazine image
 
Register today for complete access to ACHRNews.com. Get full access to the latest features, Extra Edition, and more.

STAY CONNECTED

facebook icontwitter iconyoutube iconLinkedIn i con